THỬ NGHIỆM GIA TỐC ĐÁNH GIÁ ĐỘ BỀN MỘT SỐ LOẠI SƠN KHI SỬ DỤNG TRONG ĐIỀU KIỆN KHÍ HẬU NHIỆT ĐỚI VIỆT NAM
Nội dung chính của bài viết
Tóm tắt
ACCELERATED TEST FOR DETERMINATION OF DECORATIVE AND PROTECTIVE PROPERTIES OF SOME PAINTS COATINGS BEING USED IN TROPICAL CLIMATIC CONDITIONS OF VIETNAM
This article presents result of accelerated test for determination of decorative and protective properties of five paint coatings made by Institute of Tropical Durability (ITP)/ Vietnam - Russia Tropical Centre. They are: VL-02.VN, XC-567.VN, EP-255.VN, EP-567.VN, EP-730.VN. Herewith, VL-02.VN is a primer, XC-567.VN is used for temporary protection purpose, while EP-255.VN, EP-567.VN, EP-730.VN are protective paints. These paints are intended to be used in the aviation industry. The accelerated test was lasting in 20 cycles, each cycle is equal to 24 hours. This test has been conducted in accordance with 14th method of GOST 9.401 standard, which simulates the operating conditions of paints in naturally ventilation warehouses in tropical region. The protective and decorative properties of tested paints have been assessed after 1, 3, 5, 7, 10, 15 and 20 test cycles according to both GOST 9.407 and TCVN-8785 standards. The test result shows that, the total protective rating of all the coatings (except EP-567.VN paint) is equal to 1.00, that met the requirement of GOST 9.401 standard (required rating is 1.00). So these paints are suitable for using in tropical climatic conditions. In terms of decorative property, paints EP-255.VN and EP-730.VN have a rating of 0.93, that is higher than the required rating (0.9) in relation to GOST 9.401. Paint EP-567.VN had some surface blistering defects that occurred after the 1st test cycle. However, it has been reprepared and re-tested and these defects have not appeared.
Từ khóa
Paint coating, accelerated test, protective property, decorative property
Chi tiết bài viết
Tài liệu tham khảo
2. ISO 16474-2:2013, Paints and varnishes - Methods of exposure to laboratory light sources - Part 2: Xenon-arc lamps
3. ASTM D2247-15, Standard Practice for Testing Water Resistance of Coatings in 100% Relative Humidity
4. ASTM D4585-07, Standard Practice for Testing Water Resistance of Coatings Using Controlled Condensation
5. ГОСТ 9.045-75, Покрытия лакокрасочные. Ускоренные методы определения светостойкости.
6. ГОСТ 9.083-78, Покрытия лакокрасочные. Методы ускоренных испытаний на долговечность в жидких агрессивных средах.
7. ГОСТ 9.408-86, Покрытия лакокрасочные. Метод ускоренных испытаний на стойкость в условиях хранения.
8. ГОСТ 9.401-91, Единая система защиты от коррозии и старения (ЕСЗКС). Покрытия лакокрасочные. Общие требования и методы ускоренных испытаний на стойкость к воздействию климатических факторов.
9. TCVN 8785-2:2011, Phần 2: Đánh giá tổng thể bằng phương pháp trực quan.
10. TCVN 8785-3:2011, Phần 3: Xác định độ mất màu.
11. TCVN 8785-4:2011, Phần 4: Xác định độ tích bụi.
12. TCVN 8785-5:2011, Phần 5: Xác định độ tích bụi (sau khi rửa nước).
13. TCVN 8785-6:2011, Phần 6: Xác định độ thay đổi độ bóng.
14. TCVN 8785-7:2011, Phần 7: Xác định độ mài mòn.
15. TCVN 8785-8:2011, Phần 8: Xác định độ rạn nứt.
16. TCVN 8785-9:2011, Phần 9: Xác định độ đứt gãy.
17. TCVN 8785-10:2011, Phần 10: Xác định độ phồng rộp.
18. TCVN 8785-11:2011, Phần 11: Xác định độ tạo vảy và bong tróc.
19. TCVN 8785-12:2011, Phần 12: Xác định độ phấn hóa.
20. TCVN 8785-13:2011, Phần 13: Xác định độ thay đổi màu.
21. TCVN 2097:2015, Sơn và véc ni - Phép thử cắt ô.
22. ГОСТ 9.407-15, Единая система защиты от коррозии и старения (ЕСЗКС). Покрытия лакокрасочные. Метод оценки внешнего вида.